Occupational safety instructions for a gas tanker

Free technical library

OCCUPATIONAL SAFETY AND HEALTH
Free library / Occupational Safety and Health / Standard instructions for labor protection

Instructions on labor protection for a gas filling truck. Full Document

Occupational Safety and Health

Occupational Safety and Health / Standard instructions for labor protection

Comments on the article

1. General safety requirements

1.1. Persons at least 18 years of age who have undergone a medical examination, training and instruction for the right to work, as well as those with I qualification group in electrical safety, who have passed:

induction training;
fire safety briefing;
initial briefing at the workplace;
electrical safety training.

1.2. Refueling gas station must pass:

repeated briefing on labor safety at the workplace at least once every three months;
verification of knowledge of the Rules for the Design and Safe Operation of Pressure Vessels;
unscheduled briefing in the event of an accident and an accident at work.

1.3. The refueling station operator is obliged to:

comply with the internal regulations of the enterprise;
comply with fire regulations when refueling LPG equipment;
observe the rules for the design and safe operation of pressure vessels;
comply with the requirements of this manual;
comply with safety requirements when operating the equipment;
use for its intended purpose and take care of the issued personal protective equipment;
be able to use PPE, a gas analyzer, be able to provide first aid in case of carbon monoxide poisoning, burns, electric shock.

1.4. The refueling station operator must:

perform only assigned work and not transfer it to others without the permission of the master.
during work, be attentive, not be distracted and not distract others, do not allow persons who are not related to work to the workplace;
keep the workplace clean and tidy.

1.5. The territory of the gas filling station and water intake devices must be installed in such a way that there is a possibility for wastewater to enter outside this territory.

1.6. On the territory of a gas filling station it is prohibited:

car repair;
car parking;
refueling cars with gas in the presence of gas seepage from a tank or pipeline;
storage of any materials.

1.7. Cars are allowed on the territory of a gas filling station if there are spark arresters on the exhaust pipes.

1.8. The drain and refill area must be kept clean.

1.9. The filling station operator is issued the following personal protective equipment:

when performing work on refueling cars with gas - a cotton robe, combined gloves;
for outdoor work in winter, additionally: a jacket and trousers with a warming pad, felt boots;
in the summer in addition - a waterproof raincoat.

1.10. The main hazardous and harmful production factors under certain circumstances can be:

suffocation from lack of oxygen when working in a gassed room;
increased noise;
increased pressure in the cylinders;
fire hazard;
poisoning by products of incomplete combustion of gas.

2. Safety requirements before starting work

2.1. Put on the required overalls (robe, gloves).

2.2. Check the availability of fire extinguishing equipment, uncluttered driveways, prepare refueling equipment for work, check the serviceability and availability of grounding of tanks, refueling equipment, visually check the serviceability of electrical wiring and switches.

2.3. Before filling gas cylinders, check:

serviceability of the cylinder;
tightness of threaded and flanged connections;
serviceability of shutoff valves;
serviceability of the manometer;
serviceability of safety valves.

2.4. Visually check all fastening elements of the gas-cylinder installation to the chassis of the vehicle

3. Safety requirements during work

3.1. The refueling station operator is obliged to:

turn off the engine and remove the ignition key from the lock;
make sure there is no open fire;
ground the installation and the control post;
place wheel chocks under the wheels of the car.

3.2. The car gas filling station must be installed so that gas cars drive up from the side of the meter installation.

3.3. The power cable for powering electrical equipment must be stretched to its full length so that gas-cylinder vehicles cannot run over it.

3.4. By external inspection, check the serviceability of all electrical equipment with the central switch disconnected.

3.5. Turn on the central switch.

3.6. Briefly turn on the pump, check the direction of rotation of the motor.

3.7. Start the pump according to the sequence specified in the passport for the pump:

open the valves supplying gas to the pump; bypass valve and discharge valve;
turn on the electric motor and check the operation of the pump on the bypass;
open the valve to the counter;
open the valve installed on the vapor phase pipeline and the valve for removing the vapor phase from the car cylinder.

3.8. The procedure for refueling automobile cylinders:

before filling the car cylinder, check the cylinder check stamp in the driver's waybill and the signature of the person responsible for checking them; in cars, check the inspection mark on the cylinder plate;
connect the filling clamp to the filling valve of the automobile cylinder;
open the valve on the car cylinder;
open the valve from the tank truck;
turn on the remote control;
dial on the remote control the amount of the product being dispensed;
press the "Start" button;
turn on the electric pump;
open the valve on the filling clamp (the filling process should start).

3.9. After filling the car cylinder, you must:

close the valve on the filling clamp;
turn off the pump;
disconnect the filling clamp;
make a note on the itinerary.

3.10. Put dirty cleaning material in a tightly closed metal box.

3.11. The refueling station operator is prohibited from:

work without overalls, safety shoes and other personal protective equipment provided for this type of work.
refuel cars from an autogas tanker if its exhaust manifolds and pipes (mufflers) are leaky, the ground circuit is broken, the electrical wiring is damaged, there are no fire extinguishers;
use a steel tool to clean filling places;
use an open flame, a portable lamp, electric heaters and open coils in the workplace,
make an open fire and store flammable substances in an open form;
wash hands in oil, gasoline and wipe them with rags contaminated with sawdust and shavings.
carry out repairs independently at the filling station of the electrical part of the equipment, change burned-out fuses, electric lamps, connect to the power grid, etc.;
smoking, storing food and eating in the workplace.

3.12. Do not allow vehicles with fuel leaks, pops and muffler shots to enter the gas station.

3.13. Require all drivers to strictly follow the fire safety rules at the gas station. At the refueling point, the basic safety rules for refueling vehicles must be posted in a conspicuous place.

3.14. Keep the station area and premises clean. Clean up the area at least once a day.

3.15. Closely monitor the operation of the electric motors of the fuel pumps and their switches. If heating or uneven operation of electric motors, a short circuit phenomenon is noticed, stop work immediately.

3.15. During refueling, the driver must be at the connection point of the filling clamp.

3.16. The tanker and driver must be on the windward side of the vehicle.

3.17. Operations on loading and unloading devices during lightning discharges should be stopped.

3.18. Do not wash your car with gasoline.

3.19. Do not allow unauthorized persons to enter the territory of the filling station.

4. Safety requirements in emergency situations

4.1. The most typical emergencies during the performance of work by a filling station filler can be: rupture (breakage) of filling hoses and sudden failure of filling equipment, fire.

4.2. In the event of an emergency, the filling station operator must:

immediately stop the operation of faulty equipment and turn off the power supply, warning workers of the danger;
give a fire alarm (in case of fire) and, before the arrival of help, start extinguishing the fire with available means;
notify the head of the unit and contribute to the elimination of the emergency, as well as the investigation of its causes in order to develop emergency response measures;
proceed with the elimination of the most urgent malfunctions in compliance with general safety requirements.

4.3. In the event of a malfunction that violates the operation of the fuel pumps, the latter must be stopped, checked and corrected.

4.4. In the event of a fire, call the fire brigade by phone 01, notify the management and proceed to extinguish the fire with primary means (sand, felt mat, fire extinguishers - foam, sand, carbon dioxide.

4.5. In the event of an accident or an accident, turn off the equipment, provide first aid to the victim and call an ambulance, inform the management about the incident.

5. Safety requirements after finishing work

5.1. The refueling station operator is obliged to:

close all valves on the car gas installation;
turn off all electrical equipment, disconnect plug connectors, assemble the electrical cable.

5.2. Check the order on the territory of the gas station, if necessary, restore order.

5.3. Remove protective clothing, wash hands and face with warm soapy water or take a shower. Report all comments to the garage mechanic.

We recommend interesting articles Section Standard instructions for labor protection:

▪ Waste storage conveyor. Standard instruction on labor protection

▪ Working with a cleaning tool Standard instruction on labor protection

▪ Recipient station operator. Standard instruction on labor protection

See other articles Section Standard instructions for labor protection.

Read and write useful comments on this article.

<< Back

Latest news of science and technology, new electronics:

Artificial leather for touch emulation 15.04.2024

In a modern technology world where distance is becoming increasingly commonplace, maintaining connection and a sense of closeness is important. Recent developments in artificial skin by German scientists from Saarland University represent a new era in virtual interactions. German researchers from Saarland University have developed ultra-thin films that can transmit the sensation of touch over a distance. This cutting-edge technology provides new opportunities for virtual communication, especially for those who find themselves far from their loved ones. The ultra-thin films developed by the researchers, just 50 micrometers thick, can be integrated into textiles and worn like a second skin. These films act as sensors that recognize tactile signals from mom or dad, and as actuators that transmit these movements to the baby. Parents' touch to the fabric activates sensors that react to pressure and deform the ultra-thin film. This ... >>

Petgugu Global cat litter 15.04.2024

Taking care of pets can often be a challenge, especially when it comes to keeping your home clean. A new interesting solution from the Petgugu Global startup has been presented, which will make life easier for cat owners and help them keep their home perfectly clean and tidy. Startup Petgugu Global has unveiled a unique cat toilet that can automatically flush feces, keeping your home clean and fresh. This innovative device is equipped with various smart sensors that monitor your pet's toilet activity and activate to automatically clean after use. The device connects to the sewer system and ensures efficient waste removal without the need for intervention from the owner. Additionally, the toilet has a large flushable storage capacity, making it ideal for multi-cat households. The Petgugu cat litter bowl is designed for use with water-soluble litters and offers a range of additional ... >>

The attractiveness of caring men 14.04.2024

The stereotype that women prefer "bad boys" has long been widespread. However, recent research conducted by British scientists from Monash University offers a new perspective on this issue. They looked at how women responded to men's emotional responsibility and willingness to help others. The study's findings could change our understanding of what makes men attractive to women. A study conducted by scientists from Monash University leads to new findings about men's attractiveness to women. In the experiment, women were shown photographs of men with brief stories about their behavior in various situations, including their reaction to an encounter with a homeless person. Some of the men ignored the homeless man, while others helped him, such as buying him food. A study found that men who showed empathy and kindness were more attractive to women compared to men who showed empathy and kindness. ... >>

Random news from the Archive

Chinese navigation system BeiDou 01.01.2020

After years of development, China's BeiDou (BeiDou Navigation Satellite System, BDS), which is the Chinese equivalent of the US GPS, European Galileo, and Russian GLONASS, is nearing a climax.

Project Manager Ren Chengki reported that the main constellation of BeiDou satellites has been formed - the last 56th and 57th satellites, they are also the 23rd and 24th satellites from the main constellation of the third-generation Beidou positioning system, were launched on December 23 by a Long March 3B rocket .

Since the launch of the first third-generation BeiDou satellites in November 2017, China has conducted a total of 18 launches, in which 30 satellites have been launched. In total, since 2000, when the deployment of the BeiDou satellite system began, the project has launched 57 satellites, including four test vehicles. BeiDou was launched commercially in late 2012 as a regional positioning system (in China and other parts of the Asia-Pacific region), and became global in late 2018. There are currently 46 operational Beidou satellites in orbit.

The China Satellite Navigation Office plans to place two more BeiDou satellites in geostationary orbit in the first half of 2020. Technically, this marks the completion of the third phase of Baidou's development and represents the culmination of the satellite system project in its current form. According to the project leader, the next major upgrade of BeiDou is planned no earlier than 2035.

Most Chinese users will be able to take advantage of the new global geopositioning system immediately without the need for any action. According to Nikkei, about 70% of Chinese smartphones already support BeiDou. In addition, there are already 120 partners declaring their readiness to use BeiDou for mapping.

As with Russia's GLONASS, China's desire to build its own satellite navigation system is driven by a desire to gain independence from the US and its GPS system. For China, the BeiDou system is one of the priority technology areas along with 5G and self-driving cars.

Other interesting news:

▪ Mellanox Innova IPsec 40GbE Encrypted Network Adapter

▪ Plasma based water purification system

▪ Controlled Release Fertilizers

▪ New Schottky diodes from VISHAY

▪ 3C-HSDPA technology at 63 Mbps

News feed of science and technology, new electronics

Interesting materials of the Free Technical Library:

▪ site section Tone and volume controls. Article selection

▪ article Solzhenitsyn Alexander Isaevich. Famous aphorisms

▪ article What was the subject of the dispute between the commander and the crew that caused the crash of the Soviet plane? Detailed answer

▪ article Application of metal coatings, transportation of acids and alkalis. Standard instruction on labor protection

▪ article Refinement of the Microlab B-72 speaker system. Encyclopedia of radio electronics and electrical engineering

▪ article High receiver sensitivity - by simple methods. Encyclopedia of radio electronics and electrical engineering

Leave your comment on this article:

All languages of this page

Home page | Library | Articles | Website map | Site Reviews